• Г. Шанхай, Новый район Пудун, гаоке восточная улица, 1688

flotation of copper slag in vienna

PAPER OPEN ACCESS Research on the Process of Sulphatizing ...

the simultaneous accumulation of waste induce to process generated and dump slag of copper smelting. Such slag contains 0.5-2% Cu [2]. To extract copper from slag wastes, froth flotation method is frequently used [3, 4] due to its relatively low cost. Flotation process also forms tailings with higher contents of zinc and copper than in natural ...

flotation of copper slag in iana

1energy saving flotation machine for bentonite in iana2017410 LOGIN $0 00 (0 items) Empty cartHome About Products EPC Solutisno Contact energy saving flotation machine for bentonite in ianaHome&flotation of copper slag in iana

Recover Copper from Reverberatory Furnace Slag

Recover Copper from Reverberatory Furnace Slag. Laboratory and pilot plant investigations have indicated that copper recoveries of 50% can be achieved with fine grinding and flotation of a copper reverberatory furnace slag. Microscopic and microprobe studies indicate that the recoverable copper is in the form of matte, chalcocite, and metallic ...

flotation of copper slag in sudan

Utilization of flotation wastes of copper slag as raw material in . J Hazard Mater. 2008 Nov 30;159(2 3):390 5. doi: 10.1016/j.jhazmat.2008.02.056. Epub 2008 Feb 23. Utilization of flotation wastes of copper slag as raw material in cement production.

RECOVERY OF COPPER FROM COPPER SLAG AND COPPER …

Recovery of copper from copper slag and copper slag flotation tailings 75by oxidative leaching Table 1. Chemical compositions of the copper smelter slag and the slag flotation tailings Constituent Content (wt.%) Copper Slag Slag Flotation Tailings Cu – total 0.97 0.59 Cu – oxides 0.15 0.06 Cu – sulphides 0.82 0.53 SiO 2 33.75 34.62 Al 2 O

THE EFFECT OF COOLING RATE OF SLAG FROM PRIMARY …

The content of copper in the flotation tailings directly depends on fragmentation rate (Figure 1). Expected content of copper in the flotation tailings, in the case of cooling in pits, is 0.5-0.9%, and in the case of cooling in pots, from 0.22 to 0.35% Cu. Fig. 1. The effect of fragmentation rate on the slag flotation [6]

Copper Sulfide Flotation - Mineral Processing & Metallurgy

Flowsheet for treatment of Copper Sulfide ores rich inminerals such as chalcopyrite with gold and silver as well as arsenopyrite. The above flowsheet is designed for the treatment by flotation of copper as chalcopyrite with gold and silver values. The ore, ranging from 60-65% silica, with pyrite, arsenopyrite, and calcite with 3 to 4% copper.

Andreas G. Heiss • Klaus Oeggl The oldest evidence of ...

the Near East to central Europe. In the copper ore deposits of Schwaz, in the central part of the Alps, the oldest traces of copper mining derive from the early to middle Bronze Ages. Investigation of a middle to late Bronze Age (1410-920 cal B.C.) slag-washing site in the area revealed a carbonised seed of Nigella damascena (Ranunculaceae)

Recovery of Copper from Copper Slag by Hydrometallurgy ...

The recovery of copper from copper smelter slag flotation tailings and copper smelter slag by sulphuric acid, with two different additions: ferric sulphate and hydrogen peroxide studied by [11]. It was noted that the extraction of copper increases with the increase of hydrogen peroxide addition, and the comparison between the

Expansion of the Mount Isa Mines Copper Concentrator Phase ...

of Copper Smelter converter slag began in 1976 et al, 978)_ Parallel processing of slag and ore commenced in 1992 and the flotation circuit was modified to slmpll$' parallel processmg in 1998 when it was determined that Copper Smelter Rotary Holding Fumzce (PG-IF) slag also had economic retreatment value. Slag was reated flu-ough the concentrator

Flotation Of Copper Slag In The Uk

Flotation Reagents Copper Slag. Low copper extractions both from the slag and the slag flotation tailings indicate that sulphuric acid is not a suitable reagent for leaching these materials, at room temperature. This conclusion is in line with the study by Banza et al. 2002 where the leaching of copper smelter slag with sulphuric acid 500 kgMg ...

The Recovery of Copper from Smelting Slag by Flotation ...

12%Consequently, flotation was attempted to recycle Cu in slag containing copper sulphide components. Three key factors affecting flotation were ascertained, namely, grinding fineness, the collector and the pH value, while the recovery of Cu estimated by ICP and XRF. Copper concentrate grading at 14.47 with 79.66% Cu recovery was obtained, in the ...

flotation of copper slag in jersey

Copper Slag Flotation Plant,The multicell copper slag flotation machine consists of a series of sections located at unique levels A minimum distance among the levels of person sections is 500 mm 1 section can comprise up to three cells The material comes to the flotation cell by way of a feed cell...As a leading global manufacturer of crushing equipment, milling equipment,dressing equipment ...

flotation of copper slag in brasilia

Home >> Showroom >> flotation of copper slag in brasilia . flotation of copper slag in brasilia. minerals.usgs.gov · Web view. copper, magnetic, nickel ... slag stockpiles have ... Mintek demonstrated a flotation procedure at the laboratory scale that separates platinum-group metals from ...

(PDF) Ferric leaching of copper slag flotation tailings

In this paper, the ferric leaching of slag flotation tailings is studied. Copper extractions of 66% are achieved by ferric leaching, and Cu content in tailings is reduced from 0.78% to 0.24%.

Characterisation and recovery of non-ferrous metals met in ...

overflow and in feed streams correspond well a fayalitic copper slag. These streams show a copper grade of nearly 2.5 %, a content which further increases within the flotation to around 22 %, while it drops down to 0.5 % in the rougher and final flotation tailings. The copper concentration in the hydrocyclone underflow from the ball mill is ...

Utilization of flotation wastes of copper slag as raw ...

Copper slag wastes, even if treated via processes such as flotation for metal recovery, still contain heavy metals with hazardous properties posing environmental risks for disposal. This study reports the potential use of flotation waste of a copper slag (FWCS) …

How to Recover Copper from Slag by Flotation

However, recovery of copper was about 4 percent lower for the high copper slag (sample C) and 23 percent lower for the low copper slag (sample A). Flotation tailings from the quenched slags ranged from 0.53 to 0.66 percent; slow-cooled slags gave tailings containing from only 0.26 to 0.39 percent copper with lowest analyses for 30-minute grinds.

2-Recovery of Copper and Cobalt from Converter Slag with …

Key words: Converter slag, flotation, copper, cobalt, sulphurization. 1. Introduction Copper slag is produced in large amounts in seven copper smelter plants in Chile, and it is estimated that around 4 million tons of slag are disposed every year and another …

Flotation of copper sulphide from copper smelter slag ...

The information will help in the flotation of copper smelter slag for better copper grade and recovery. Abstract Present work focuses on the differences in the performances obtained in the froth flotation of copper smelter slag with multiple collector viz. sodium iso-propyl xanthate (SIPX), sodium di-ethyl dithiophosphate (DTP) and alkyl ...

「flotation of copper slag in singapore」

Flotation using flocculants for copper sulphide ore.flotation of copper slag in kampalamovieorgin there are four grinding and flotation lines sequentially yielding a copper and designed by outokumpu with input from kennecott plus a slag treatment plant.more info flotation of copper oxide oresshaheenpublicschool.

Optimization of the flotation of copper smelter slags from ...

Optimization of the flotation of copper smelter slags from Namibia Custom Smelters' Slag Mill Plant Elias Sipunga A research report submitted to the Faculty of Engineering and the Built Environment, University of the Witwatersrand, in partial fulfillment of the requirements for the degree of Master of Science in Engineering

Copper Recovery Through Smelter Slag Flotation in Atacama ...

Copper slag flotation was studied on an industrial scale at a concentrator plant in the region of Atacama, Chile. This study consisted of the physical, chemical, and mineralogical characterization of the copper slag, along with preliminary flotation tests.

Extractive Metallurgy: Efficiency and Eco-friendliness ...

Characterization of copper smelter slag and recovery of residual metals from these residues ... Austria. 3.-RHI AG, Wienerbergstrasse 9, 1100 Vienna, Austria. 4.- ... ''Recovery of Copper from Cyanidation Tailing by Flotation,'' Tingsheng Qiu et al. validate the feasibility of extracting copper from copper minerals in cyanidation ...

flotation of copper slag which is strong

of which is strong enough for lique ... the direct production of copper from ... metallic copper concentrate from slag flotation and/or copper cement are. Inquire Now; durable used flotation plant_Xinhai stillbhs.org. Jun 16, 2017· SF Flotation Cell. Introduction:SF flotation cell is a mechanical agitation type flotation equipment with self ...

Recovery of metal values from copper slags by flotation ...

For an air-cooled slag at optimized conditions, 72% of copper was recovered in one stage flotation and a 12.6% copper concentrate was achieved. The best recovery efficiency was obtained when 30 g ...

flotation of copper slag in morocco

Utilization of flotation wastes of copper slag as raw material in . J Hazard Mater. 2008 Nov 30;159(2 3):390 5. doi: 10.1016/j.jhazmat.2008.02.056. Epub 2008 Feb 23. Utilization of flotation wastes of copper slag as raw material in cement production.

Recovery of Copper and Silver by Flotation from Smelting ...

The recovery of copper from smeltery furnace slag by flotation has been studied. By analysis the slag containing 1.61% copper and 27.80g/t silver is available to recovery. The effective factors such as particle size, the amount and type of collector were examined. The combination of the collectors was also examined. With the process utilized in this work, a copper concentrate of 26.47% Cu with ...

Recovery Of Copper From Reverberatory Furnace Slag By ...

copper slag recycling plants ... metal oxides and produces impure copper and an iron rich slag that. at a ... from reverberatory furnace slag by flotation May 12, 2013 · A process for the recovery of iron from copper slag which ... The 20 Mt reverberatory furnace slag dump at Nkana in Zambia ... banded iron ore flotation;

-Experimental study on enhanced flotation …

Abstract:The copper slag of a smelter in Yunnan contains 2.21% Cu, which mainly occurs in the form of copper sulfide, copper oxide and copper metal.In this paper, after the fine grinding of the copper slag, Z-200 and hydrocarbon oil KYY were used for enhanced flotation, and the effects of fineness of grinding, type and dosage of agents and times of scavenging on the Cu recovery were …